Optimizing Diode Structure in Uncooled Infrared Focal Plane Array
-
摘要: 为适应非制冷红外探测器高空间分辨率的发展趋势,非制冷红外焦平面阵列作为非制冷红外探测器的核心部件不断向大阵列、小像素方向发展。本文针对二极管型非制冷红外焦平面阵列,理论分析了敏感元件二极管对读出电路以及器件性能的影响,在确定二极管最佳工作电流的同时,提炼出二极管结构中串联个数以及结面积为主要性能影响因素。基于此,设计了p+n-pn-n+p三合一二极管,并将其与传统二极管、回型二极管、p+n-n+p二合一二极管、以及由p+n-n+p二合一二极管直接拓展得到的两种三合一二极管进行了对比考察,研究发现6种结构中p+n-pn-n+p三合一二极管在相同尺寸下拥有最多的二极管串联数量且结面积相对最大;进而利用Sentaurus TCAD仿真,验证了在同一整体尺寸下,p+n-pn-n+p三合一二极管的电压温度系数分别约为p+n-n+p二合一二极管,及在其基础上直接拓展得到的两种三合一二极管的1.5倍,为回型二极管与传统二极管的2.6倍、3.7倍。证明了在小像素下p+n-pn-n+p三合一二极管性能最优,且在其基础上拓展可得到N合一二极管能进一步优化器件的性能。
-
关键词:
- 二极管非制冷红外探测器 /
- 噪声等效温差 /
- 电压温度系数 /
- 三合一二极管
Abstract: To adapt to the development trend of high-spatial-resolution of uncooled infrared detectors, the uncooled infrared focal plane array (IR FPA), which is the core component of uncooled infrared detectors, is constantly developing towards larger arrays and smaller pixels. Aiming at the diode-type IR FPA, this paper theoretically analyzes the influence of the sensitive element diode on the readout circuit and device performance. While determining the best operating current of the diode, the number of series connected in the diode structure and junction area are the leading performance factors. Based on this conclusion, a p+n-pn-n+p 3-in-1 diode was designed and combined with traditional diodes, "well"-shape diodes, p+n-n+p 2-in-1 diodes, and two 3-in-1 diodes obtained by the direct expansion of p+n-n+p 2-in-1 diodes, which were compared and investigated. The study found that the p+n-pn-n+p 3-in-1 diodes of the six structures had the most significant number of diodes in series under the same size, and the relative junction area was the largest. Using Sentaurus TCAD simulation, it was verified that under the same overall size, the voltage temperature sensitivity (TCV) value of the p+n-pn-n+p 3-in-1 diodes is approximately that of the p+n-n+p 2-in-1 diode, and two types diode of 3-in-1 obtained by direct expansion on the p+n-n+p 2-in-1 diode was 1.5 times, which is 2.6 times and 3.7 times the "well" shape diode and traditional diode, respectively. It is proved that the performance of the p+n-pn-n+p 3-in-1 diode is the best under small pixels, and the expansion of the N-in-1 diode can further optimize the device performance. -
表 1 6种结构同尺寸下的Z值与N值的大小
Table 1. The Z value and N value under the same size of 6 structures
Structure Aa/μm2 Sa/μm2 Z N a 30 30×30 0.0333 1 b 840 30×30 0.9333 1 c 727 30×30 0.8070 2 d 726 30×30 0.8067 3 e 645 30×30 0.7167 3 f 741.2 30×30 0.8236 3 -
[1] LIU C, FU J, HOU Y, et al. An effective method for evaluating thermal parameters of diode-based thermal sensors[J]. Measurement, 2020, 156: 107621. doi: 10.1016/j.measurement.2020.107621 [2] 余黎静, 唐利斌, 杨文运, 等. 非制冷红外探测器研究进展(特邀)[J]. 红外与激光工程, 2021, 50(1): 20211013-1-20211013-15. https://www.cnki.com.cn/Article/CJFDTOTAL-HWYJ202101010.htmYU Lijing, TANG Libin, YANG Wenyun, et al. Research progress of uncooled infrared detectors(Invited)[J]. Infrared and Laser Engineering, 2021, 50(1): 20211013-1-20211013-15. https://www.cnki.com.cn/Article/CJFDTOTAL-HWYJ202101010.htm [3] 冯涛, 金伟其, 司俊杰. 非制冷红外焦平面探测器及其技术发展动态[J]. 红外技术, 2015, 37(3): 177-184. http://hwjs.nvir.cn/article/id/hwjs201503001FENG Tao, JIN Weiqi, SI Junjie. Uncooled Infrared FPA--A Review and Forecast[J]. Infrared Technology, 2015, 37(3): 177-184. http://hwjs.nvir.cn/article/id/hwjs201503001 [4] 黄卓磊. 二极管型非制冷红外成像技术研究[D]. 北京: 中国科学院微电子研究所, 2015.HUANG Zhuolei. Research on Diode Uncooled Infrared Imaging Technology [D]. Beijing: Institute of Microelectronics, Chinese Academy of Sciences, 2015. [5] 李静, 宋广, 董珊, 等. 非制冷红外焦平面探测器研究进展与趋势[J]. 红外, 2020, 41(10): 1-14, 24. https://www.cnki.com.cn/Article/CJFDTOTAL-HWAI202010001.htmLI Jing, SONG Guang, DONG Shan, et al. Progress and Trend of Uncooled Infrared Focal Plane Detectors[J]. Infrared, 2020, 41(10): 1-14, 24. https://www.cnki.com.cn/Article/CJFDTOTAL-HWAI202010001.htm [6] Hanaoka M, Kosasayama Y, Hata H, et al. 80×32 SOI diode-based uncooled IRFPAs for thermal detectors[C]//Infrared Technology and Applications XLVII, 2021, 11741: 1174112. [7] Ishikawa T, Ueno M, Nakaki Y, et al. Performance of 320×240 uncooled IRFPA with SOI diode detectors[C]//Infrared Technology and Applications XXVI, 2000, 4130: 152-159. [8] Fujisawa D, Maegawa T, Ohta Y, et al. Two-million-pixel SOI diode uncooled IRFPA with 15µm pixel pitch[C]//Infrared Technology and Applications XXXVIII, 2012, 8353: 83531G. [9] Fujisawa D, Hanaoka M, Kosasayama Y, et al. Development of new pixel structure for beyond 12-µm pixel pitch SOI diode uncooled IRFPAs[C]//Infrared Technology and Applications XLVI. International Society for Optics and Photonics, 2020, 11407: 114071A. [10] SHEU M L, SUN T P, Shie M C. Measurement of Dark Current of Infrared Detector in Focal Plane Array[C]//Proceedings of 12th VLSI Design/CAD Symposium, 2001: B3-8. [11] 张强, 刘瑞文, 吕文龙, 等. 非制冷热敏二极管型红外焦平面阵列电压温度系数的分析与优化[J]. 微纳电子技术, 2018, 55(9): 617-624. https://www.cnki.com.cn/Article/CJFDTOTAL-BDTQ201809001.htmZHANG Qiang, LIU Ruiwen, LV Wenlong, et al. Analysis and optimization of the voltage temperature coefficient of a thermodiode uncooled infrared focal plane array[J]. Micronanoelectronic Technology, 2018, 55(9): 617-624. https://www.cnki.com.cn/Article/CJFDTOTAL-BDTQ201809001.htm [12] Takamuro D, Maegawa T, Sugino T, et al. Development of new SOI diode structure for beyond 17 μm pixel pitch SOI diode uncooled IRFPAs[C]//Infrared Technology and Applications XXXVII, 2011, 8012: 80121E. [13] 刘恩科, 朱秉升, 罗晋生. 半导体物理学[M]. 北京: 电子工业出版社, 2008: 156-180.LIU Enke, ZHU Bingsheng, LUO Jingsheng. Semiconductor Physics[M]. Beijing: Publishing House of Electronics Industry, 2008: 156-180. [14] 刘子骥, 赵晟晨, 赵征庭, 等. 非制冷红外焦平面阵列器件的热时间常数测试方法[J]. 红外与激光工程, 2019, 48(12): 1204003-1204003. https://www.cnki.com.cn/Article/CJFDTOTAL-HWYJ201912014.htmLIU Ziji, ZHAO Shengchen, ZHAO Zhengting, et al. A test method of thermal time constant for uncooled infrared focal plane array[J]. Infrared and Laser Engineering, 2019, 48(12): 1204003-1204003. https://www.cnki.com.cn/Article/CJFDTOTAL-HWYJ201912014.htm [15] ZHOU Shichun. Introduction to Advanced Infrared Optoelectronic Engineering[M]. Beijing: Science Press, 2014: 171-264. [16] 吕玉菲. 25 μm像素尺寸SOI二极管型红外焦平面阵列的研究[D]. 北京: 中国科学院大学, 2015.LYU Yufei. Research on 25μm Pixel Size SOI Diode Type Infrared Focal Plane Array[D]. Beijing: University of Chinese Academy of Sciences, 2015. [17] Ueno M, Kosasayama Y, Sugino T, et al. 640×480 pixel uncooled infrared FPA with SOI diode detectors[C]//Infrared Technology and Applications XXXI. International Society for Optics and Photonics, 2005, 5783: 566-577.