940 nm滤光片的设计、制备及低角度效应的研究

唐家建; 沈龙海; 仲维平; 李想; 罗皓

940 nm滤光片的设计、制备及低角度效应的研究

沈阳理工大学理学院, 辽宁沈阳 110000

基金项目:

沈阳理工大学大学生创新创业训练计划项目 S202010144004

详细信息

作者简介:
唐家建（1999-），男，大学本科，主要从事光电薄膜制备方面研究。E-mail：2018918030@qq.com

通讯作者:
沈龙海（1977-），男，博士，教授，主要从事光电薄膜制备与物性的研究。E-mail：shenlonghai@163.com

中图分类号: O484.4
计量
- 文章访问数: 154
- HTML全文浏览量: 55
- PDF下载量: 43
- 被引次数: 0
出版历程
- 收稿日期: 2021-08-30
- 修回日期: 2021-10-28
- 刊出日期: 2022-10-20

Design and Fabrication of 940 nm Filter and Research on Its Low Angle Effect

School of Science, Shenyang Ligong University, Shenyang 110000, China

摘要

摘要: 本文对人脸识别中使用的940 nm窄带滤光片进行设计及制备，研制一种具有低角度效应的窄带滤光片。选择TiO₂、SiO₂作为高、低折射率材料，在Essential Macleod软件中对膜系进行设计，通过改变间隔层材料对膜系进行优化，最终设计的膜系层数为11，膜系总厚度为2480.76 nm。采用电子束热蒸发沉积技术对薄膜进行镀制，使用傅里叶红外光谱仪完成透射率光谱特性测试。最终研制的滤光片中心波长为940 nm，在截止区间（200~1100 nm）内，通带透射率大于80%，平均截止透射率小于1%，0°~22°通带偏移量为14 nm。
- 光学薄膜 /
- 窄带滤光片 /
- 人脸识别 /
- 角度效应
Abstract: In this study, a 940-nm narrowband filter used for face recognition is designed and examined and a narrowband filter with low angle effect is developed. TiO₂ and SiO₂ are chosen as high and low refractive index materials, respectively. The film system is designed by using the Essential Macleod software and optimized by changing the material of the spacer layer. The film system has 11 layers and a total thickness of 2480.76 nm. The thin film is plated by using the electron beam thermal evaporation deposition technology, and the transmittance spectral characteristics are tested using a Fourier infrared spectrometer. The center wavelength of the finally developed filter is 940 nm. In the cut-off range (200 to 1100 nm), the pass-band transmittance is greater than 80%, average cut-off transmittance is less than 1%, and offset at 0° to 22° passband is 14 nm.
- optical thin film /
- narrow band-pass filter /
- face recognition /
- angle effect

HTML全文

图 1 基础膜系中不同入射角的透射率曲线

Figure 1. Transmittance curves of different incident angles in the basic film system

下载: 全尺寸图片幻灯片

图 2 优化后的膜系中不同入射角的透射率曲线

Figure 2. Transmittance curves of the optimized film system at different incident angles

下载: 全尺寸图片幻灯片

图 3 镀制完成的940 nm窄带滤光片

Figure 3. Coated 940 nm narrowband filter

下载: 全尺寸图片幻灯片

图 4 入射角为0°和22°时透射率光谱曲线

Figure 4. The transmittance spectrum curves when the incident angle is 0° and 22°

下载: 全尺寸图片幻灯片

图 5 局部放大的通带区间透射率光谱曲线

Figure 5. Partially amplified passband transmittance spectrum curves

下载: 全尺寸图片幻灯片

参考文献(14)

[1]	K D Hendrix, R A Bradley, M Grigonis, et al. Optical Filter and Sensor System: United States, 9354369[P]. [2013-7-16].
[2]	毛克宁. 可见光波段角度不敏感滤光片的研究[D]. 杭州: 浙江大学, 2016: 3-8. MAO Kening. Angle Insensitive Color Filters Covering the Visible Region[D]. Hangzhou: Zhejiang Umiversity, 2016: 3-8.
[3]	刘冬梅, 岳鹏飞, 付秀华, 等. 低角度效应虹膜识别滤光片的研制[J]. 光学学报, 2019, 39(11): 396-403. https://www.cnki.com.cn/Article/CJFDTOTAL-GXXB201911048.htm LIU Dongmeu, YUE Pengfei, FU Xiuhua, et ai. Development of iris recognition filter with low-angle effect[J]. Acta Optica Sinica, 2019, 39(11): 396-403. https://www.cnki.com.cn/Article/CJFDTOTAL-GXXB201911048.htm
[4]	魏博洋, 刘冬梅, 付秀华, 等. 基于结构光3D成像技术的945 nm窄带滤光片研制[J]. 激光与光电子学进展, 2021, 58(14): 498-506. https://www.cnki.com.cn/Article/CJFDTOTAL-JGDJ202114055.htm WEI Boyang, LIU Dongmei, FU Xiuhua, et al. Development of a 945-nm narrowband filter based on a structured light 3D imaging technology[J]. Laser & Optoelectronics Progress, 2021, 58(14): 498-506. https://www.cnki.com.cn/Article/CJFDTOTAL-JGDJ202114055.htm
[5]	李珊. 905 nm窄带滤光片的设计与制备[D]. 长春: 长春理工大学, 2010. LI Shan. Study and Fabrication of 905 nm Narrow Band-pass Filter[D]. Changchun: Changchun University of Science and Technology, 2010.
[6]	贾钰超, 李刚, 白玉琢, 等. 窄带滤光片设计中通带半宽度、矩形度和陡度的影响因素研究[J]. 红外技术, 2012, 34(8): 448-452. https://www.cnki.com.cn/Article/CJFDTOTAL-HWJS201208003.htm JIA Yuchao, LI Gang, BAI Yuzhuo, et al. Study of factors influencing half bandwidth, rectangularity and steepness in design of narrow band-pass filter[J]. Infrared Technology, 2012, 34(8): 448-452. https://www.cnki.com.cn/Article/CJFDTOTAL-HWJS201208003.htm
[7]	Macleod H Angus. Thin-Film Optical Filters[M]. Fourth Edition: London: CRC Press, 2012.
[8]	顾培夫, 李海峰, 章岳光, 等. 用于倾斜入射的波分复用薄膜滤光片的特性及改进[J]. 光学学报, 2003, 23(3): 377-380. doi: 10.3321/j.issn:0253-2239.2003.03.025 GU Peifu, LI Haifeng, ZHANG Yueguang, et al. Characteristics and improvement of dense wavelength division multiplexing (DWDM) thin film filters used in tilted used in tilted incidence [J]. Acta Optica Sinica, 2003, 23(3): 377-380. doi: 10.3321/j.issn:0253-2239.2003.03.025
[9]	查家明, 李斯成, 唐乾隆. 红外中带滤光片的结构、带宽估算及调整[J]. 应用光学, 2007, 28(2): 151-155. https://www.cnki.com.cn/Article/CJFDTOTAL-YYGX200702012.htm ZHA Jiaming, LI Sicheng, TANG Qianlong. Structure, bandwidth estimation and adjustment of medium band-pass infrared filter [J]. Journal of Applied Optics, 2007, 28(2): 151-155. https://www.cnki.com.cn/Article/CJFDTOTAL-YYGX200702012.htm
[10]	侯海港, 刘桂武, 邵海成, 等. 窄带滤光片设计中敏感度的影响因素[J]. 江苏大学学报(自然科学版), 2018, 39(4): 420-424. doi: 10.3969/j.issn.1671-7775.2018.04.009 HOU Haigang, LIU Guiwu, SHAO Haicheng, et al. Influence factors on sensitivity in design of narrow band-pass filter band [J]. Journal of Jiangsu University(Natural Science Edition), 2018, 39(4): 420-424. doi: 10.3969/j.issn.1671-7775.2018.04.009
[11]	翁煜菲. 红外窄带滤光片的倾斜入射性能改善研究[J]. 集成电路应用, 2020, 37(6): 35-37. https://www.cnki.com.cn/Article/CJFDTOTAL-JCDL202006013.htm WENG Yufei. Study on improvement of inclined incidence performance of infrared narrow band filter[J]. Application of IC, 2020, 37(6): 35-37. https://www.cnki.com.cn/Article/CJFDTOTAL-JCDL202006013.htm
[12]	周言敏, 李建芳, 王君. 基于组合法的850 nm~950 nm滤光片设计与制备[J]. 安徽电子信息职业技术学院学报, 2012, 11(6): 39-41. https://www.cnki.com.cn/Article/CJFDTOTAL-AHDJ201206010.htm ZHOU Yanmin, LI Jianfang, WANG Jun. 850 nm to 950 nm filter design and preparation based on the set of legal[J]. Journal of Anhui Vocational College of Electronics & Information Technology, 2012, 11(6): 39-41. https://www.cnki.com.cn/Article/CJFDTOTAL-AHDJ201206010.htm
[13]	刘长亮. 近红外宽截止窄带滤光膜的研制[D]. 长春: 长春理工大学, 2014. LIU Changliang. Research on Near-infrared Narrowband Filters with Wide Rejection Band [D]. Changchun: Changchun University of Science and Technology, 2014.
[14]	王建, 徐均琪, 苏俊宏, 等. 850 nm滤光片的设计、制备及激光损伤特性[J]. 表面技术, 2020, 49(3): 112-118. https://www.cnki.com.cn/Article/CJFDTOTAL-BMJS202003015.htm WANG Jian, XU Junqi, SU Junhong, et al. Design, fabrication and laser damage characteristics of optical filters using at the wavelength of 850 nm [J]. Surface Technology, 2020, 49(3): 112-117. https://www.cnki.com.cn/Article/CJFDTOTAL-BMJS202003015.htm